Ca-γ-Al2O3耦合酸溶液催化葡萄糖制5-HMF

摘要针对以葡萄糖为原料制备5-羟甲基糠醛（5-HMF）的问题，开发了CaO杂化的γ-Al₂O₃球形颗粒[Ca-γ-Al₂O₃，粒径1.8（±0.1） mm]耦合酸溶液制备过程，采用XRD与BET对Ca-γ-Al₂O₃球形颗粒进行了表征，研究了CaO杂化量、溶剂酸浓度、溶剂中二甲基亚砜（DMSO）与水的比例、催化剂用量、反应温度与时间对反应效果的影响，并评价了Ca-γ-Al₂O₃的操作稳定性，探讨了催化机理。实验结果表明：CaO的杂化（杂化量10%）对颗粒的孔结构影响相对较小，且在Ca-γ-Al₂O₃上分布较为均匀。在0.05 mol·L^-1酸浓度、V（DMSO）/V（H₂O）=3∶1、葡萄糖与催化剂比例为2∶1（125 mg∶63 mg）、反应温度140℃与反应时间3 h下，以Ca （5%）-γ-Al₂O₃为催化剂，葡萄糖转化率为100%，5-HMF收率最高为58.6％。此外，Ca-γ-Al₂O₃循环操作（未煅烧）5次后，5-HMF收率略有降低至55％左右，同时杂化负载方式使得CaO在酸性溶液中的泄露较低，表明Ca-γ-Al₂O₃具有良好的操作稳定性。催化剂机理分析表明，Ca-γ-Al₂O₃具有良好的葡萄糖异构化能力，CaO的杂化可提高催化剂与葡萄糖的相互作用，果糖脱水过程主要依赖于酸溶液的催化。

	Service

	把本文推荐给朋友
	加入我的书架
	加入引用管理器
	Email Alert
	RSS
	作者相关文章
	王康
	贾传奇
	林芳

关键词：葡萄糖 5-羟甲基糠醛氧化钙氧化铝杂化

Abstract： The method of γ-Al₂O₃ spherical beads doped CaO (Ca-γ-Al₂O₃, beads size 1.8±0.1 mm) coupling with an acid solution was developed for preparing 5-hydroxymethylfurfural (5-HMF) from glucose. The Ca-γ-Al₂O₃ spherical beads were characterized by XRD and BET. Also, the effects of the doping amount of CaO, the concentration of solvent acid, the ratio of dimethyl sulfoxide (DMSO) to water in the solvent, the amount of catalyst, the reaction temperature and time on the catalytic performance were analyzed. Besides, the operational stability of Ca-γ-Al₂O₃ and the catalytic mechanism were evaluated and discussed respectively. The experimental results show that the doping amount of CaO (doping amount10%) has little effect on the pore structure of the particles. Furthermore, 100% glucose conversion and the highest yield of 5-HMF with 58.6% is obtained under the following conditions:0.05 mol·L^-1 acid concentration, V(DMSO):V(H₂O)=3:1, the ratio of glucose to catalyst=2:1 (125 mg:63 mg),the reaction temperature of 140℃ and the reaction time of 3 h. Moreover, after 5 cycles of Ca-γ-Al₂O₃ operation (not calcined), the 5-HMF yield reduces slightly to about 55%, and the leakage of CaO in acidic solution is lower due to the doping approach, which indicate that Ca-γ-Al₂O₃ had good operational stability. Hence, the catalysis mechanism shows that Ca-γ-Al₂O₃ has excellent glucose isomerization ability. The doping of CaO can improve the interaction between the catalyst and glucose and the dehydration process of fructose mainly depends on the catalysis of acid solution.

Keywords： glucose 5-hydroxymethyl furfural calcium oxide aluminum oxide doping

Received 2020-11-14;

Fund:国家重点研发计划子项目（2017YFB0306502）。

Corresponding Authors: 王康,E-mail:wangk72@tju.edu.cn。 Email: wangk72@tju.edu.cn

About author: 王康(1972-)女,博士,副教授,现从事催化剂设计与生物材料方面的研究。

引用本文:

王康, 贾传奇, 林芳.Ca-γ-Al₂O₃耦合酸溶液催化葡萄糖制5-HMF[J]. 化学工业与工程, 2021,38(5): 20-26

Wang Kang, Jia Chuanqi, Lin Fang.Catalytic Dehydration of Glucose to 5-HMF by Ca-γ-Al₂O₃ and Acid Solution[J]. Chemcial Industry and Engineering, 2021,38(5): 20-26

[1] Zakzeski J, Bruijnincx P C A, Jongerius A L, et al. The catalytic valorization of lignin for the production of renewable chemicals[J]. Chemical Reviews, 2010, 110(6):3552-3599
[2] Fang R, Luque R, Li Y. Selective aerobic oxidation of biomass-derived HMF to 2, 5-diformylfuran using a MOF-derived magnetic hollow Fe-Co nanocatalyst[J]. Green Chemistry, 2016, 18(10):3152-3157
[3] Zhang Z, Zhen J, Liu B, et al. Selective aerobic oxidation of the biomass-derived precursor 5-hydroxymethylfurfural to 2, 5-furandicarboxylic acid under mild conditions over a magnetic palladium nanocatalyst[J]. Green Chemistry, 2015, 17(2):1308-1317
[4] Huber G W. Production of liquid alkanes by aqueous-phase processing of biomass-derived carbohydrates[J]. Science, 2005, 308(5727):1446-1450
[5] Qi X, Watanabe M, Aida T M, et al. Catalytic dehydration of fructose into 5-hydroxymethylfurfural by ion-exchange resin in mixed-aqueous system by microwave heating[J]. Green Chemistry, 2008, 10(7):799-805
[6] Jadhav A H, Kim H, Hwang I T. An efficient and heterogeneous recyclable silicotungstic acid with modified acid sites as a catalyst for conversion of fructose and sucrose into 5-hydroxymethylfurfural in superheated water[J]. Bioresource Technology, 2013, 132:342-350
[7] Ordomsky V V, Van der Schaaf J, Schouten J C, et al. Fructose dehydration to 5-hydroxymethylfurfural over solid acid catalysts in a biphasic system[J]. Chem Sus Chem, 2012, 5(9):1812-1819
[8] Solis M C, Rivera de la Rosa J, Lucio-Ortiz C J, et al. Synthesis and characterization of functionalized alumina catalysts with thiol and sulfonic groups and their performance in producing 5-hydroxymethylfurfural from fructose[J]. Fuel, 2017, 198:134-144
[9] Zhang M, Su K, Song H, et al. The excellent performance of amorphous Cr₂O₃, SnO₂, SrO and graphene oxide-ferric oxide in glucose conversion into 5-HMF[J]. Catalysis Communications, 2015, 69:76-80
[10] Marianou A A, Michailof C M, Pineda A, et al. Effect of Lewis and Brønsted acidity on glucose conversion to 5-HMF and lactic acid in aqueous and organic media[J]. Applied Catalysis A:General, 2018, 555:75-87
[11] García-Sancho C, Fúnez-Núñez I, Moreno-Tost R, et al. Beneficial effects of calcium chloride on glucose dehydration to 5-hydroxymethylfurfural in the presence of alumina as catalyst[J]. Applied Catalysis B:Environmental, 2017, 206:617-625
[12] Takagaki A, Jung J C, Hayashi S. Solid Lewis acidity of boehmite γ-AlO(OH) and its catalytic activity for transformation of sugars in water[J]. RSC Adv, 2014, 4(82):43785-43791
[13] Yu I, Xiong X, Tsang D C W, et al. Aluminium-biochar composites as sustainable heterogeneous catalysts for glucose isomerisation in a biorefinery[J]. Green Chemistry, 2019, 21(6):1267-128
[14] Yang C, Lu X, Lin W, et al. TG-FTIR study on corn straw pyrolysis-influence of minerals[J]. Chemical Research in Chinese Universities, 2006, 22(4):524-532
[15] Combs E, Cinlar B, Pagan-Torres Y, et al. Influence of alkali and alkaline earth metal salts on glucose conversion to 5-hydroxymethylfurfural in an aqueous system[J]. Catalysis Communications, 2013, 30:1-4
[16] Sampath G, Srinivasan K. Remarkable catalytic synergism of alumina, metal salt and solvent for conversion of biomass sugars to furan compounds[J]. Applied Catalysis A:General, 2017, 533:75-80
[17] Lin F, Wang K, Gao L, et al. Efficient conversion of fructose to 5-hydroxymethylfurfural by functionalized γ-Al₂O₃ beads[J]. Applied Organometallic Chemistry, 2019, doi:10.1002/aoc.4821
[18] 王康,朱士贞,董安华,等. PtSnLa/Ca-Al₂O₃作为异丁烷脱氢催化剂的研究[J] 天津大学学报:自然科学与工程技术版,2017,50(10):1105-1110 Wang Kang, Zhu Shizhen, Dong Anhua, et al. Study on PtSnLa/Ca-Al₂O₃ as a catalyst for isobutane dehydrogenation[J]. Journal of Tianjin University:Science and Technology,2017, 50(10):1105-1110(in Chinese)
[19] 王康,董安华,张业岭,等. 海藻酸辅助制备CeO₂/Al₂O₃ 颗粒及其催化臭氧化亚甲基蓝[J]. 天津大学学报:自然科学与工程技术版,2017,50(3):276-282 Wang Kang, Dong Anhua, Zhang Yeling, et al. Degradation of methylene blue by catalytic ozonation over CeO₂/Al₂O₃ catalyst synthesized by alginate assisted sol-gel method[J]. Journal of Tianjin University:Science and Technology,2017,50(3):276-282(in Chinese)
[20] 王康,孟广莹,杨文建,等. 海藻酸辅助溶胶-凝胶法制备球形氧化铝颗粒[J]. 天津大学学报:自然科学与工程技术版,2014,47(12):1052-1056 Wang Kang, Meng Guangying, Yang Wenjian, et al. Preparation of spherical alumina by alginate assisted sol-gel method[J]. Journal of Tianjin University:Science and Technology,2014,47(12):1052-1056(in Chinese)
[21] Aellig C, Hermans I. Continuous D-fructose dehydration to 5-hydroxymethylfurfural under mild conditions[J]. ChemSusChem, 2012, 5(9):1737-1742