石化企业VOCs排放检测方法及影响因素研究

摘要对青岛某炼厂的挥发性有机物进行采样和分析，对比了2种不同材质气袋的储存稳定性，同时在控制光照和是否加入保护气的条件下进行采样分析。得出结论，针对炼厂固定源挥发性有机物，聚酯铝（PEA）气袋的平均回收率（79.6%±4.0%）明显优于泰德拉（PVF）气袋（72.9%±4.0%）。且光照和保护气的加入会对实验结果产生一定程度的影响。

	Service

	把本文推荐给朋友
	加入我的书架
	加入引用管理器
	Email Alert
	RSS
	作者相关文章
	朱诗月
	赵朝成
	韩丰磊

关键词：挥发性有机物气袋光照保护气

Abstract： Samples of volatile organic compounds were collected from a refinery in Qingdao. The storage stability of two kinds of airbags with different materials was compared. At the same time, the samples were analyzed under the conditions of the control of light and whether the protective gas was added. It was concluded that the average recovery of PEA(polyester aluminum) air bags (79.6%±4.0%) was significantly better than that of PVF(polyvinyl fluoride) air bags(72.9%±4.0%) for stationary volatile organic compounds in the refinery. And light and protective gas will have a certain degree of impact on the experimental results.

Keywords： volatile organic compounds； air bag； light； protective gas

Received 2018-03-09;

Fund:HSE实验新方法研究（2016D500608）。

Corresponding Authors: 赵朝成,E-mail:zhaochch@upc.edu.cn。 Email: zhaochch@upc.edu.cn

About author: 朱诗月(1993-),女,硕士研究生,现从事环境监测技术方面的研究。

引用本文:

朱诗月, 赵朝成, 韩丰磊.石化企业VOCs排放检测方法及影响因素研究[J]. 化学工业与工程, 2019,36(4): 7-17

Zhu Shiyue, Zhao Chaocheng, Han Fenglei.Research on VOCs Emission Detection Methods and Influencing Factors in Petrochemical Enterprises[J]. Chemcial Industry and Engineering, 2019,36(4): 7-17

[1] 贾树昌. 中国石油大港石化公司挥发性有机物(VOCs)综合治理设计研究[D]. 山东青岛:青岛理工大学, 2017 Jia Shuchang. PetroChina Dagang petrochemical industries costudy on the comprehensive treatment of volatile organic compounds(VOCs)[D]. Shandong Qingdao:Qingdao Tehcnology University, 2017(in Chinese)
[2] Ghosh S, Kim K H, Sohn J R. Some insights into analytical bias involved in the application of grab sampling for volatile organic compounds:A case study against used Tedlar bags[J]. The Scientific World Journal, 2011, 11:2160-2177
[3] Gierczak C A, Andino J M, Butler J W, et al. FTIR:Fundamentals and applications in the analysis of dilute vehicle exhaust[J]. Proceedings of SPIE-The International Society for Optical Engineering, 1991, 1433:315-328
[4] Woolfenden E. Review:Optimising analytical performance and extending the application range of thermal desorption for indoor air monitoring[J]. Indoor and Built Environment, 2001, 10(3/4):222-231
[5] Chandra B P, Sinha V, Hakkim H, et al. Storage stability studies and field application of low cost glass flasks for analyses of thirteen ambient VOCs using proton transfer reaction mass spectrometry[J]. International Journal of Mass Spectrometry, 2017, 419:11-19
[6] Kim Y H, Kim K H, Jo S H, et al. Comparison of storage stability of odorous VOCs in polyester aluminum and polyvinyl fluoride Tedlar^® bags[J]. Analytica Chimica Acta, 2012, 712:162-167
[7] Kim K H, Park S Y. A comparative analysis of malodor samples between direct (olfactometry) and indirect (instrumental) methods[J]. Atmospheric Environment, 2008, 42(20):5061-5070
[8] Steeghs M M L, Cristescu S M, Harren F J M. The suitability of Tedlar bags for breath sampling in medical diagnostic research[J]. Physiological Measurement, 2007, 28(1):73-84
[9] 徐威力. 气袋采样在非甲烷总烃分析中的应用初探[J]. 轻工科技, 2014, 30(5):113-113,115 Xu Weili. Application of airbag sampling in analysis of non-methane total hydrocarbons[J]. Light Industry Science and Technology, 2014, 30(5):113-113,115(in Chinese)
[10] 邹兵, 李鹏, 高少华, 等. 炼化装置泄漏检测与维修(LDAR)现状及发展趋势[J]. 安全·健康和环境, 2013, 13(2):1-4 Zou Bing, Li Peng, Gao Shaohua, et al. Current status and development trend of leak detection and repair for refining units[J]. Safety Health & Environment, 2013, 13(2):1-4(in Chinese)
[11] Woolfenden E. Monitoring VOCs in air using sorbent tubes followed by thermal desorption-capillary GC analysis:Summary of data and practical guidelines[J]. Journal of the Air & Waste Management Association, 1997, 47(1):20-36