纳米流体黏度和流变特性的试验研究

摘要对纳米流体黏度和流变特性的研究有助于揭示纳米流体强化传热和传质过程的机理。选用无水乙醇为基液，应用两步法制备了稳定性良好的纳米流体，采用CPE40锥板式黏度计测量了不同纳米粒子、体积份额、粒子粒径和温度下的纳米流体的黏度，分析了黏度随这些因素的变化规律。结果表明，纳米流体黏度随纳米粒子体积份额的增加而增大，随纳米粒子粒径的增大而减小，随温度的增加而降低，且这些因素对不同纳米流体黏度的影响不同。此外，还用Brookfield DVⅢ+LVDVE流变仪测量了不同纳米流体的流变曲线，结果表明，在所配制的体积份额内，各纳米流体的黏度不随剪切速率的变化而变化，为典型的牛顿型流体

	Service

	把本文推荐给朋友
	加入我的书架
	加入引用管理器
	Email Alert
	RSS
	作者相关文章
	.唐忠利
	彭林明
	张树杨

关键词：纳米流体黏度传热和传质流变特性

Abstract： The research of viscosity and rheological properties will help reveal the mechanisms on the heat and mass transfer of nanofluids.Nanofluids were prepared using a twostep method with the ethanol as the base fluid，the viscosity was measured using the CPE40 coneplate viscometer under different kinds of nanoparticles，different volume fraction，different particle size and temperature conditions.The effect of these factors on the viscosity of nanofluids was also analyzed accordingly.The results indicate that the viscosity of nanofluids increases with increasing particle concentration，and decreases with increasing particle size and temperature.However，the effect of various factors on the viscosity of the nanofluids with different nanoparticles is different.In addition，the rheological properties of these nanofluids were also measured by using Brookfield DVⅢ+LVDVE rheometer.The results also demonstrated that these nanofluids were Newtonian fluids.

Keywords： nanofluids viscosity heat and mass transfer rheological properties

Received 2011-10-17;

Fund:

国家自然科学基金资助项目（20876108）

Corresponding Authors: 唐忠利，电话：（022）23503863转3402，Email：zltang@tju.edu.cn Email: zltang@tju.edu.cn

About author: 唐忠利(1969-），男，陕西西安人，副教授，主要从事传质与分离、煤化工和纳米流体等的研究。

引用本文:

唐忠利, 彭林明, 张树杨.纳米流体黏度和流变特性的试验研究[J]. 化学工业与工程, 2012,29(3): 1-5

Tang-Zhong-Li , PENG Lin-Ming, ZHANG Shu-Yang.Experimental Study of Viscosity and Rheological Properties of Nanofluids[J]. Chemcial Industry and Engineering, 2012,29(3): 1-5

[1]	CHOI S U S.Developments and applications of nonNewtonian flows［J］.American Society of Mechanical Engineering,1995,231：66-99
[2]	LI Q，XUAN Y.Heat transfer enhancement of nanofluids［J］.Journal of Engineering Thermophysics，2000，21(4）:466-470
[3]	LI Q，XUAN Y.Experimental investigations on transport properties of magnetic fluids[J].Experimental Thermal and Fluid Science.2005,30(2):109-116
[4]	LEE J K，KOO J，HONG H, et al.The effects of nanoparticles on absorption heat and mass transfer performance in NH₃/H₂O binary nanofluids[J].International Journal of Refrigeration.2010,33(2):269-275
[5]	KIM S，KIM C，LEE W H，et al.Rheological properties of alumina nanofluids and their implication to the heat transfer enhancement mechanism[J].Journal of Applied Physics.2011,110(3):1-6
[6]	KRISHNAMURTY S，BHATTACHA P，PHELAN P E.Enhanced mass transport in nanofluids[J].Nano Letters.2006,6(3):419-423
[7]	OLLE B，BUCAK S，HOMLES T C，et al.Enhancement of oxygen mass transfer using functionalized magnetic nanoparticles［J］.Industrial and Engineering Chemistry Research，2006,45(12）:4 355-4 363
[8]	KANG Y T，KIM H J，LEE K I.Heat and mass transfer enhancement of binary nanofluids for H₂O/LiBr falling film absorption process[J].International Journal of Refrigeration.2008,31(5):850-856
[9]	HU Z，DONG J.Study on antiwear and reducing friction additive of nanometer titanium oxide[J].Wear.1998,216(1):92-96
[10]	胡纪华,杨兆禧,郑忠.胶体与界面化学［M］.广州:华南理工大学出版社，1997
[11]	李新芳,朱冬生.Cu-H₂O纳米流体的黏度研究［J］.湖南工程学院学报,2009,19(2）:21-24
[12]	HERIS S Z,ETEMAD S G,ESFAHANY M N. Experimental investigation of oxide nanofluids laminar flowconvective heat transfer[J].International Communication in Heat and Mass Transfer.2006,33:529-535
[13]	李泽梁,李俊明,王补宣，等.SDBS对氧化铜纳米粒子悬浮液黏度的影响[J].工程热物理学报.2003,24(5):849-851
[14]	XUAN Y，LI Q.Heat transfer enhancement of nanofluids [J].International Journal of Heat and Fluid Flow.2000,21(1):58-64
[15]	王补宣,周乐平,彭晓峰.纳米粒子悬浮液的黏度、热扩散系数与Pr数[J].自然科学进展.2004,14(7):799-803
[16]	DAS S K,PUTRA N,ROETZEL W.Pool boiling characteristics of nanofluids [J].International Journal of Heat and Mass Transfer.2003,46(5):851-862
[17]	KWAK K，KIM C.Viscosity and thermal conductivity of copper oxide nanofluid dispersed in ethylene glycol［J］.KoreaAustralia Rheology Journal，2005，2(17）：35-40
[18]	刘玉东,周跃国,童明伟，等.TiO₂ -H₂O纳米流体流变特性的实验研究［J］.材料导报:研究篇,2009，23(3）：14-16
[19]	NAMBURU P K，KULKARNI D P，MISR A,et al.Viscosity of copper oxide nanoparticles dispersed in ethylene glycol and water mixture [J].Experimental Thermal and Fluid Science.2007,32(2):397-402
[20]	 ［20］BARTHELMESAG，PRATSINIS S E，BUGGISH H.Particle size distributions and viscosity of suspensions undergoing shearinduced coagulation and fragmentation［J］.Chemical Engineering Science，2003，58(13）：2 893-2 902
[21]	郭顺松,王涛.SiO₂纳米流体黏度研究［J］.硅酸盐通报,2006,25(5）：52-55
[22]	张树杨.纳米流体强化气液传质研究［D］.天津:天津大学,2010