ZSM-5分子筛膜的形成过程及其影响因素

摘要采用打磨法在多孔-αAl2O3载体上引入尺寸为100 nm的分子筛晶种,再用水热法合成了ZSM-5分子筛膜。考察了合成液中硅铝比、水硅比和碱度等对成膜的影响,并对合成的膜进行SEM、XRD表征。结果表明,在反应液配比为n(SiO2)∶n(Al2O3)∶n(Na2O)∶n(NBA)∶n(H2O)=100.0∶1.0∶9.0∶20.0∶3 000.0时,合成分子筛膜最好,膜厚约为11μm。并通过不同时间下的膜的SEM图表征膜的成膜过程,成膜主要是液相机制起作用,即存在于溶液中硅酸根和铝酸根离子在晶种的表面上缩聚使晶体长大。

	Service

	把本文推荐给朋友
	加入我的书架
	加入引用管理器
	Email Alert
	RSS
	作者相关文章
	王立娜
	李永红

关键词：水热合成影响因素 ZSM-5沸石膜

Abstract： The ZSM-5 membranes was synthesized on porous alumina substrates coated with nanosized ZSM-5 seeds by using manual rubbing method and then employing the hydrothermal synthesis.The effects of(n(SiO_2)∶)n(Al_2O_3), n(H_2O)∶n(SiO_2) and n(Na_2O∶SiO_2) on the membrane formation were thoroughly evaluated.The optimum reaction mixture composition is 100.0 SiO_2-1.0 Al_2O_3-20.0 NBA-9.0 Na_2O-(3 000.0) H_2O and the membrane thickness was approximately 11 μm.The formation mechanism of the zeolite membrane was shown by SEM.The crystalline mechanism of liquid phase acts as essentially.The condensation polymerization of Al(OH)_4~-and SiO_2(OH)_2~-in the reaction solution at seeds surface brought about the crystal to grow up.

Keywords：

Received 2006-11-15; published 2006-11-15

引用本文:

王立娜;李永红;.ZSM-5分子筛膜的形成过程及其影响因素[J]. 化学工业与工程, 2006,23(6): 475-479

WANG Li-na,LI Yong-hong.Factors Affecting the Synthesis of ZSM-5 Zeolite Membranes and Its Formation Process[J]. Chemcial Industry and Engineering, 2006,23(6): 475-479

[1]	张雄福,王金渠.ZSM-5沸石膜的合成及成膜因素研究[J].石油学报(石油加工),2001,17(3):9.
[2]	LAI R,GAVALAS G R.Surface seeding in ZSM-5membrane preparation[J].Ind Eng Chem Res,1998,37(11):4 275-4 283.
[3]	LOVALLO M C,GOUZINIS A,TSAPATSIS M.Synthesisand characterization of oriented MFI membranes prepared bysecondary growth[J].AIChE J.1998,44(8):1903-
[4]	张雄福,王金渠.用喷涂晶种法合成ZSM-5沸石膜及其影响因素[J].催化学报,2000,21(5):451-454.
[5]	程志林,晁自胜.添加成膜促进剂合成致密ZSM-5分子筛膜[J].化学学报,2003,61(12):1 944-1 948.
[6]	HEDLUND J,NOACK M,KOLSCH P,et al.ZSM-5membranes synthesized without organic templates using aseeding technique[J].J Membr Sci.1999,159:263-
[7]	XOMERITAKIS G,NAIR S,TSAPATSIS M.Transportproperties of alumina-supported MFI membranes made bysecondary(seeded)growth[J].Microporous andMesoporous Materials.2000,38:61-
[8]	KITA H,HORII K,OHTOSHI Y,et al.Synthesis of azeolite NaA membrane for pervaporation of water-organicliquid mixture[J].J Membr Sci Lett,1995,14:206.
[9]	王金渠,王国强.ZSM-5沸石膜合成中几个影响因素[J].大连理工大学学报,1998,38(6):654-658.
[10]	KOEHLER H,BEKKUM H V,JANSEN J C.Growthmodel of oriented crystals of zeolite Si-ZSM-5[J].Zeolites.1997,19:262-
[11]	DEN EXTER M J,BEKKUM H V,RIJN C J M,et al.Stability of oriented silicalite-1 films in view of zeolitemembrane preparation[J].Zeolites.1997,19:13-
[12]	JUNG M K,KIM M H,HONG S S.Aging effects in thesynthesis of ZSM-5 film[J].Microporous and MesoporousMaterials.1998,26:153-159
[13]	LAI R,YAN Yu-shan,GAVALAS G R.Growth of ZSM-5films on alumina and other surfaces[J].Microporous andMesoporous Materials.2000,37:9-19