季铵盐-醇疏水性低共熔溶剂分离镍和钴

文章导读

摘要疏水性低共熔溶剂(HDES)是一种新型的绿色溶剂,具有成本低、蒸汽压低和合成简单等优点。以三辛基甲基氯化铵(Aliquat 336)为氢键受体,正己醇、正辛醇、正癸醇、正十二醇和正十四醇分别为氢键供体制备了5种HDES,用于Co(Ⅱ)和Ni(Ⅱ)的萃取分离。考察了Cl^-浓度、酸度和温度对萃取分离性能的影响,研究了Co(Ⅱ)的反萃行为,并采用紫外-可见吸收光谱和红外吸收光谱分析了HDES萃取Co(Ⅱ)的机理。结果表明,增加Cl^-浓度、升高温度、降低酸度,可以改善Co(Ⅱ)和Ni(Ⅱ)的分离效果。不同的HDES相比,增加氢键供体的烷基链长度,Co(Ⅱ)和Ni(Ⅱ)的分配比略有下降,分离因子基本不变。萃入HDES的Co(Ⅱ)可采用1 mol·L^-1 Na₂SO₄溶液反萃,经过二级反萃,可以将99.5%的Co(Ⅱ)反萃到水相。5种HDES萃取Co(Ⅱ)的机理相同,为阴离子交换。

	Service

	把本文推荐给朋友
	加入我的书架
	加入引用管理器
	Email Alert
	RSS
	作者相关文章
	何喜红
	肖海锋
	李林波

关键词：疏水性低共熔溶剂萃取钴/镍分离氢键供体

Abstract： Hydrophobic deep eutectic solvent (HDES) is a new type of green solvent with low cost, low vapour pressure, simple synthesis and other advantages. Using Aliquat 336 as hydrogen bond acceptor and hexyl alcohol, capryl alcohol, decyl alcohol, dodecyl alcohol, myristyl alcohol as hydrogen bond donor, respectively, five HDES were prepared for the extraction and separation of Co(Ⅱ) and Ni(Ⅱ). The effects of Cl^- concentration, acidity and temperature were investigated, the stripping behavior of Co(Ⅱ) was studied, and the extraction mechanism of Co(Ⅱ) by HDES was studied by ultraviolet-visible spectroscopy and Fourier transform infrared spectroscopy. The results show that the separation performance of Co(Ⅱ) and Ni(Ⅱ) can be improved by increasing Cl^- concentration, increasing temperature and decreasing acidity. Compared with different HDESs, the distribution ratios of Co(Ⅱ) and Ni(Ⅱ) decreased slightly with the increase of alkyl chain length in hydrogen bond donor, and the separation factors remained unchanged. The Co(Ⅱ) can be stripped from the HDESs phase with 1 mol·L^-1 Na₂SO₄ solution, and the stripping percentage reached 99.5% by two times of stripping. The extraction mechanism of Co(Ⅱ) by five HDESs is the same which accords with anion exchange.

Keywords： hydrophobic deep eutectic solvent extraction Co/Ni separation hydrogen bond donor

Received 2021-11-18;

Fund:陕西省自然科学基础研究项目(2021JM-370)。

Corresponding Authors: 李林波,教授,E-mail:yj-lilinbo@xauat.edu.cn Email: yj-lilinbo@xauat.edu.cn

About author: 何喜红(1984-),男,博士,副教授,现从事有色金属冶金新工艺新技术方面的研究。

引用本文:

何喜红, 肖海锋, 李林波.季铵盐-醇疏水性低共熔溶剂分离镍和钴[J]. 化学工业与工程, 2023,40(2): 67-74

HE Xihong, XIAO Haifeng, LI Linbo.Separation of cobalt and nickel by hydrophobic deep eutectic solvents based on quaternary ammonium salt and alcohols[J]. Chemcial Industry and Engineering, 2023,40(2): 67-74

[1] FLETT D S. Cobalt-nickel separation in hydrometallurgy: A review[J]. Chemistry for sustainable development, 2004,12(1): 81-91
[2] PARK K H, MOHAPATRA D. Process for cobalt separation and recovery in the presence of nickel from sulphate solutions by Cyanex 272[J]. Metals and Materials International, 2006, 12(5): 441-446
[3] 李亮. 钴镍的溶剂萃取分离工艺研究综述[J]. 湖南有色金属, 2015, 31(6): 51-54 LI Liang. Research review on the separation of cobalt and nickel by solvent extraction[J]. Hunan Nonferrous Metals, 2015, 31(6): 51-54(in Chinese)
[4] TAIT B K. Cobalt-nickel separation: The extraction of cobalt(Ⅱ) and nickel(Ⅱ) by Cyanex 301, Cyanex 302 and Cyanex 272[J]. Hydrometallurgy, 1993, 32(3): 365-372
[5] DEVI N B, NATHSARMA K C, CHAKRAVORTTY V. Separation and recovery of cobalt(Ⅱ) and nickel(Ⅱ) from sulphate solutions using sodium salts of D2EHPA, PC 88A and Cyanex 272[J]. Hydrometallurgy, 1998, 49(1/2): 47-61
[6] 李英, 张利华, 郭胜惠, 等. P₅₀₇微乳液膜萃取分离钴镍研究[J]. 有色金属工程, 2016, 6(6): 40-44 LI Ying, ZHANG Lihua, GUO Shenghui, et al. Extraction and separation of cobalt from nickel by P₅₀₇ microemulsion liquid membrane[J]. Nonferrous Metals Engineering, 2016, 6(6): 40-44(in Chinese)
[7] SWAIN N, PRADHAN S, MISHRA S. Efficiency of Aliquat 336 for hydrometallurgical separation of Sm(Ⅲ) and Co(Ⅱ) from nitrate medium[J]. Minerals Engineering, 2019, doi:10.1016/j.mineng.2019.105872
[8] 徐志刚, 季尚军, 王朝华, 等. 溶液中镍钴萃取分离技术研究状况[J]. 湿法冶金, 2018, 37(5): 342-348 XU Zhigang, JI Shangjun, WANG Chaohua, et al. Review on separation of nickel and cobalt in solution by solvent extraction technology[J]. Hydrometallurgy of China, 2018, 37(5): 342-348(in Chinese)
[9] WELLENS S, THIJS B, BINNEMANS K. An environmentally friendlier approach to hydrometallurgy: Highly selective separation of cobalt from nickel by solvent extraction with undiluted phosphonium ionic liquids[J]. Green Chemistry, 2012, doi: 10.1039/c2gc35246j
[10] TIECCO M, CAPPELLINI F, NICOLETTI F, et al. Role of the hydrogen bond donor component for a proper development of novel hydrophobic deep eutectic solvents[J]. Journal of Molecular Liquids, 2019, 281: 423-430
[11] JANICKA P, PRZYJAZNY A, BOCZKAJ G. Novel "acid tuned" deep eutectic solvents based on protonated L-proline[J]. Journal of Molecular Liquids, 2021, doi:10.1016/j.molliq.2021.115965
[12] SOROURADDIN S M, FARAJZADEH M A, OKHRAVI T. Development of dispersive liquid-liquid microextraction based on deep eutectic solvent using as complexing agent and extraction solvent: Application for extraction of heavy metals[J]. Separation Science and Technology, 2020, 55(16): 2955-2966
[13] MENGHWAR P, YILMAZ E, SHERAZI S T H, et al. A sensitive and selective deep eutectic solvent-based ultrasound-assisted liquid phase microextraction procedure for separation-preconcentration and determination of copper in olive oil and water samples[J]. Separation Science and Technology, 2019, 54(15): 2431-2439
[14] ZHU X L, XU C Y, TANG J, et al. Selective recovery of zinc from zinc oxide dust using choline chloride based deep eutectic solvents[J]. Transactions of Nonferrous Metals Society of China, 2019, 29(10): 2222-2228
[15] CAO J, YANG M, CAO F L, et al. Well-designed hydrophobic deep eutectic solvents as green and efficient media for the extraction of artemisinin from Artemisia annua leaves[J]. ACS Sustainable Chemistry & Engineering, 2017, 5(4): 3270-3278
[16] VAN OSCH D J G P, DIETZ C H J T, WARRAG S E E, et al. The curious case of hydrophobic deep eutectic solvents: A story on the discovery, design, and applications[J]. ACS Sustainable Chemistry & Engineering, 2020, doi:10.1021/acssuschemeng.0c00559
[17] RIBEIRO B D, FLORINDO C, IFF L C, et al. Menthol-based eutectic mixtures: Hydrophobic low viscosity solvents[J]. ACS Sustainable Chemistry & Engineering, 2015, 3(10): 2469-2477
[18] VAN OSCH D J G P, PARMENTIER D, DIETZ C H J T, et al. Removal of alkali and transition metal ions from water with hydrophobic deep eutectic solvents[J]. Chemical Communications, 2016, 52(80): 11987-11990
[19] OLA P D, MATSUMOTO M. Use of deep eutectic solvent as extractant for separation of Fe (Ⅲ) and Mn(Ⅱ) from aqueous solution[J]. Separation Science and Technology, 2019, 54(5): 759-765
[20] HANADA T, GOTO M. Synergistic deep eutectic solvents for lithium extraction[J]. ACS Sustainable Chemistry & Engineering, 2021, 9(5): 2152-2160
[21] TAYSUN M B, SERT E, ATALAY F S. Effect of hydrogen bond donor on the physical properties of benzyltriethylammonium chloride based deep eutectic solvents and their usage in 2-ethyl-hexyl acetate synthesis as a catalyst[J]. Journal of Chemical & Engineering Data, 2017, 62(4): 1173-1181
[22] SCHAEFFER N, MARTINS M A R, NEVES C M S S, et al. Sustainable hydrophobic terpene-based eutectic solvents for the extraction and separation of metals[J]. Chemical Communications (Cambridge, England), 2018, 54(58): 8104-8107
[23] CAO J, YANG M, CAO F, et al. Tailor-made hydrophobic deep eutectic solvents for cleaner extraction of polyprenyl acetates from Ginkgo biloba leaves[J]. Journal of Cleaner Production, 2017, 152: 399-405
[24] MAKOŚ P, PRZYJAZNY A, BOCZKAJ G. Hydrophobic deep eutectic solvents as "green" extraction media for polycyclic aromatic hydrocarbons in aqueous samples[J]. Journal of Chromatography A, 2018, 1570: 28-37
[25] WASSINK B, DREISINGER D, HOWARD J. Solvent extraction separation of zinc and cadmium from nickel and cobalt using Aliquat 336, a strong base anion exchanger, in the chloride and thiocyanate forms[J]. Hydrometallurgy, 2000, 57(3): 235-252
[26] PARHI P K, PANIGRAHI S, SARANGI K, et al. Separation of cobalt and nickel from ammoniacal sulphate solution using Cyanex 272[J]. Separation and Purification Technology, 2008, 59(3): 310-317
[27] SOBEKOVA FOLTOVA S, VANDER HOOGERSTRAETE T, BANERJEE D, et al. Samarium/cobalt separation by solvent extraction with undiluted quaternary ammonium ionic liquids[J]. Separation and Purification Technology, 2019, 210: 209-218
[28] BARRERA N M, MCCARTY J L, DRAGOJLOVIC V. Effects of concentration on hexaaquacobalt(Ⅱ)/tetrachlorocobalt(Ⅱ) equilibrium. A discovery-oriented experiment for chemistry students[J]. The Chemical Educator, 2002, 7(3): 142-145
[29] LIU Y, LEE M S. Separation of cobalt and nickel from chloride leach solution of nickel laterite ore by solvent extraction[J]. Geosystem Engineering, 2016, 19(5): 214-221
[30] GENG Y, XIANG Z, LV C, et al. Recovery of gold from hydrochloric medium by deep eutectic solvents based on quaternary ammonium salts[J]. Hydrometallurgy, 2019, 188: 264-271
[31] 申婧, 杜志平, 李恩泽, 等. 离子液体对Cd(Ⅱ)的萃取性能的研究[J]. 工业水处理, 2017, 37(2): 87-90 SHEN Jing, DU Zhiping, LI Enze, et al. Research on the extraction capacity of ionic liquid for Cd(Ⅱ)[J]. Industrial Water Treatment, 2017, 37(2): 87-90(in Chinese)