半干法脱硫渣矿化CO<sub>2</sub>与解吸AMP溶剂反应研究

文章导读

摘要采用半干法脱硫工艺产生的脱硫渣对吸收了CO₂的有机胺溶剂进行化学解吸并矿化CO₂,解吸后的溶剂具有良好的循环稳定性。对比了工业常用的4种有机胺MEA、DEA、MDEA和AMP的吸收-矿化性能,优选出AMP作为吸收矿化工艺的吸收剂。考察了脱硫渣颗粒粒径、搅拌转速、有机胺浓度和反应温度对矿化反应转化率的影响,并利用表面覆盖模型对实验数据进行了动力学拟合。物料和能量衡算结果表明脱硫渣矿化再生工艺在能耗成本方面相较传统热再生工艺具有优势。

	Service

	把本文推荐给朋友
	加入我的书架
	加入引用管理器
	Email Alert
	RSS
	作者相关文章
	王彦
	宋磊
	马奎
	岳海荣
	梁斌

关键词： CO₂捕集脱硫渣吸收矿化工艺化学吸收法

Abstract： Amine solvents were chemically desorbed by the semi-dry desulfurization slag (DFS) and showed cycle stabilities. With the comparison of the absorption and mineralization properties of four commonly used amines, such as MEA、DEA、MDEA and AMP, AMP was selected as the absorbent for the process. The effects of particle size, stirring speed, amine concentration, and reaction temperature on the mineralization reaction were investigated. The surface coverage model was used to dynamically fit the experimental data and the materials and energy consumption of the overall process were calculated. The results show that the absorption-mineralization process with DFS had advantages over the thermal regeneration process in terms of energy consumption and cost.

Keywords： CO₂ capture desulfurization slag (DFS) absorption-mineralization process chemical desorption

Received 2021-05-19;

Fund:国家重点研发项目(2018YFB0605700)。

Corresponding Authors: 岳海荣,教授,E-mail:hryue@scu.edu.cn Email: hryue@scu.edu.cn

About author: 王彦(1994-),男,硕士研究生,从事CO₂捕集矿化方面研究。

引用本文:

王彦, 宋磊, 马奎, 岳海荣, 梁斌.半干法脱硫渣矿化CO₂与解吸AMP溶剂反应研究[J]. 化学工业与工程, 2023,40(2): 1-8

WANG Yan, SONG Lei, MA Kui, YUE Hairong, LIANG Bin.Research on coupling the AMP solvent with semidry desulfurization slag to absorb and mineralize CO₂[J]. Chemcial Industry and Engineering, 2023,40(2): 1-8

[1] ROCHELLE G T. Amine scrubbing for CO₂ capture[J]. Science, 2009, 325(5948): 1652-1654
[2] CHANG J, HOU C, WAN D, et al. Enhanced CO₂ adsorption capacity of bi-amine co-tethered flue gas desulfurization gypsum with water of hydration[J]. Journal of CO₂ Utilization, 2020, 35: 115-125
[3] ALI S B Z, GAO H, HUANG Y, et al. Enhancing CO₂ desorption performance in rich MEA solution by addition of SO^2-₄/ZrO₂/SiO₂ bifunctional catalyst[J]. Applied Energy, 2019, doi:10.1016/j.apenergy.2019.113440
[4] NWAOHA C, SMITH D W, IDEM R, et al. Process simulation and parametric sensitivity study of CO₂ capture from 115 MW coal-fired power plant using MEA-DEA blend[J]. International Journal of Greenhouse Gas Control, 2018, 76: 1-11
[5] SHANGGUAN W J, SONG J, YUE H, et al. An efficient milling-assisted technology for K-feldspar processing, industrial waste treatment and CO₂ mineralization[J]. Chemical Engineering Journal, 2016, 292: 255-263
[6] BENHELAL E, RASHID M I, RAYSON M S, et al. Study on mineral carbonation of heat activated lizardite at pilot and laboratory scale[J]. Journal of CO₂ Utilization, 2018, 26: 230-238
[7] JI L, YU H, YU B, et al. Integrated absorption-mineralisation for energy-efficient CO₂ sequestration: Reaction mechanism and feasibility of using fly ash as a feedstock[J]. Chemical Engineering Journal, 2018, 352: 151-162
[8] JI L, YU H, LI K, et al. Integrated absorption-mineralisation for low-energy CO₂ capture and sequestration[J]. Applied Energy, 2018, 225: 356-366
[9] YU B, YU H, LI K, et al. A diamine-based integrated absorption-mineralization process for carbon capture and sequestration: Energy savings, fast kinetics, and high stability[J]. Environmental Science & Technology, 2018, 52(22): 13629-13637
[10] YU B, YU H, YANG Q, et al. Postcombustion capture of CO₂ by diamines containing one primary and one tertiary amino group: Reaction rate and mechanism[J]. Energy & Fuels, 2019, 33(8): 7500-7508
[11] LIU M, GADIKOTA G. Single-step, low temperature and integrated CO₂ capture and conversion using sodium glycinate to produce calcium carbonate[J]. Fuel, 2020, doi: 10.1016/j.fuel.2020.117887
[12] ZHANG W, LI J, WANG Q, et al. Desorption and mineralization of CO₂ in amine-based solution by Ca(OH)₂[J]. International Journal of Greenhouse Gas Control, 2020, doi:10.1016/j.ijggc.2020.103056
[13] AROONWILAS A, VEAWAB A. Integration of CO₂ capture unit using blended MEA-AMP solution into coal-fired power plants[J]. Energy Procedia, 2009, 1(1): 4315-4321
[14] PAN S, CHIANG P, CHEN Y, et al. Kinetics of carbonation reaction of basic oxygen furnace slags in a rotating packed bed using the surface coverage model: Maximization of carbonation conversion[J]. Applied Energy, 2014, 113: 267-276
[15] CHANG E, CHIU A C, PAN S, et al. Carbonation of basic oxygen furnace slag with metalworking wastewater in a slurry reactor[J]. International Journal of Greenhouse Gas Control, 2013, 12: 382-389
[16] DASH S K, SAMANTA A N, BANDYOPADHYAY S S. Simulation and parametric study of post combustion CO₂ capture process using (AMP+PZ) blended solvent[J]. International Journal of Greenhouse Gas Control, 2014, 21: 130-139