乙酸异丙酯-异丙醇-DMSO的等压汽液相平衡和萃取精馏模拟

摘要

在101.3 kPa压力下，采用汽液平衡釜测定了二元物系异丙醇+二甲基亚砜（DMSO）、乙酸异丙酯+DMSO和三元物系异丙醇+乙酸异丙酯+DMSO的汽液平衡数据。利用Van Ness点校验法检验以上气液平衡数据，结果表明，数据符合热力学一致性。采用NRTL、Wilson和UNIQUAC活度系数模型对二元数据进行了拟合，并进行了三元物系汽液相平衡数据预测，结果表明，回归数据和实验数据吻合良好。Wilson模型的预测结果优于NRTL和UNIQUAC模型。一定量DMSO的加入可消除异丙醇和乙酸异丙酯的共沸点，因此，DMSO可作为一种有效的萃取剂来萃取精馏分离此二元物系。然后，通过流程模拟软件Aspen Plus，使用获得的二元交互作用参数对三元系统的萃取精馏进行了模拟。讨论了在不同的操作条件（塔板数、进料位置、溶剂比和回流比）下，异丙醇和乙酸异丙酯分离的情况，得到了最适宜的操作条件。

	Service

	把本文推荐给朋友
	加入我的书架
	加入引用管理器
	Email Alert
	RSS
	作者相关文章
	李嘉琪
	丁辉
	高郁杰
	刘涉江

关键词：异丙醇；乙酸异丙酯；二甲基亚砜；汽液相平衡

Abstract：

The vapor-liquid equilibrium (VLE) data for the binary system isopropyl alcohol+dimethyl sulfoxide (DMSO), isopropyl acetate+DMSO and ternary system isopropyl alcohol+isopropyl acetate+DMSO were measured with a VLE modified Othmer still at 101.3 kPa. The experimental data were proved to be thermodynamically consistent when the point to point consistency test of Van Ness test was applied. The binary experimental data were correlated with the NRTL, Wilson and UNIQUAC activity coefficient models. Then, the ternary VLE data were predicted with the obtained binary interaction parameters. The results indicate that the calculated values are in good agreement with the experimental data. The results predicted by the Wilson models are slight better than those of other models. The binary azeotrope of isopropyl alcohol and isopropyl acetate was eliminated when added a certain amount of DMSO. Therefore, DMSO is a potential extractive agent to separate the azeotrope. Then, the extractive distillation of the ternary system was simulated using obtained binary interaction parameters with the process simulation software Aspen Plus. The separation conditions of isopropyl alcohol and isopropyl acetate with different operational parameters (stage number, feed stage, solvent ratio and reflux ratio) were discussed and the optimum conditions were achieved.

Keywords： isopropyl alcohol； isopropyl acetate； dimethyl sulfoxide； vapor liquid equilibrium

Received 2016-03-28;

Fund:

国家自然科学基金（21376166）。

Corresponding Authors: 刘涉江,E-mail:liushejiang@tju.edu.cn。 Email: liushejiang@tju.edu.cn

About author: 李嘉琪(1989-),女,硕士研究生,现从事化工分离方向研究。

引用本文:

李嘉琪, 丁辉, 高郁杰, 刘涉江.乙酸异丙酯-异丙醇-DMSO的等压汽液相平衡和萃取精馏模拟[J]. 化学工业与工程, 2017,34(6): 62-69

Li Jiaqi, Ding Hui, Gao Yujie, Liu Shejiang.Vapor-Liquid Equilibria and Simulation of Extractive Distillation for Ternary Mixtures of Isopropyl Alcohol, Isopropyl Acetate and DMSO[J]. Chemcial Industry and Engineering, 2017,34(6): 62-69

[1] 高江霞. 病房呼叫器的带菌状况及异丙醇消毒湿巾的消毒效果[J]. 甘肃医药, 2015, 34(5):385-386 Gao Jianxia. The study of Ward pager and the disinfection effect of isopropyl alcohol disinfection wet wipes[J]. Gansu Medicine, 2015, 34(5):385-386(in Chinese)
[2] Yamashita K, Tanaka T, Hayashi M. Use of isopropyl alcohol as a solvent in Ti(O-i-Pr) 4-catalyzed Knöevenagel reactions[J]. Tetrahedron, 2005, 61(33):7981-7985
[3] 王彦民, 张付申, 宋凤敏, 等. 废弃电子塑料在超临界异丙醇中的液化特性[J]. 中国环境科学, 2014,(12):3142-3149 Wang Yanmin, Zhang Fushen, Song Fengmin, et al. The liquefaction characteristics of electronic waste plastic in supercritical isopropyl alcohol[J]. China Environmental Science, 2014(12):3142-3149(in Chinese)
[4] Yilgor E, Atilla G E, Ekin A, et al. Isopropyl alcohol:An unusual, powerful, ‘green’ solvent for the preparation of silicone-urea copolymers with high urea contents[J]. Polymer, 2003, 44(26):7787-7793
[5] 补朝阳. 乙酸异丙酯的合成[J]. 化学研究, 2014, 25(6):601-603 Bu Chaoyang. The synthesis of isopropyl acetate[J]. Chemical research, 2014, 25(6):601-603(in Chinese)
[6] 朱勇强, 周仕林, 谢来苏. 动态滤水实验方法的探讨[J]. 中国造纸, 1999,(2):26-29 Zhu Yongqiang, Zhou Shilin, Xie Laisu. The discusstion of dynamic filtering of water[J]. China Pulp & Paper, 1999, (2):26-29(in Chinese)
[7] 许前会, 张秋荣. 连续反应精馏合成乙酸异丙酯[J]. 辽宁化工, 2003, 32(12):510-511 Xu Qianhui, Zhang Qiurong. The synthesis of isopropyl acetate by the continuous reaction distillation[J]. Liaoning chemical, 2003, 32(12):510-511(in Chinese)
[8] Zhang B, Yang W, Hu S, et al. A reactive distillation process with a sidedraw stream to enhance the production of isopropyl acetate[J]. Chemical Engineering & Processing, 2013, 70(3):117-130
[9] 李亚楠. 乙酸异丙酯催化加氢制备异丙醇和乙醇工艺研究[D]. 辽宁大连:大连理工大学, 2014 Li Yanan. The study of Isopropyl acetate preparation isopropyl alcohol and ethanol by catalytic hydrogenation technology[D]. Liaoning Dalian:Dalian University of Technology, 2014(in Chinese)
[10] Lee L S, Kuo M Z. Phase and reaction equilibria of the acetic acid-isopropanol-isopropyl acetate-water system at 760 mmHg[J]. Fluid Phase Equilibria, 1996, 123(s1/2):147-165
[11] Andreatta A E, Arce A, Rodil E, et al. Physical properties and phase equilibria of the system isopropyl acetate+isopropanol+1-octyl-3-methyl-imidazolium bis(trifluoromethylsulfonyl)imide[J]. Fluid Phase Equilibria, 2010, 287(2):84-94
[12] Andreatta A E, Francisco M, Rodil E, et al. Isobaric vapour-liquid equilibria and physical properties for isopropylacetate+isopropanol+1-butyl-3-methyl-imidazolium bis(trifluoromethylsulfonyl)imide mixtures[J]. Fluid Phase Equilibria, 2011, 300(s1/2):162-171
[13] Marcus Y. Ionic and molar volumes of room temperature ionic liquids[J]. Journal of Molecular Liquids, 2015, 209:289-293
[14] Yang X, Zhang X, Guo Z, et al. Effects of incompatible substances on the thermal stability of dimethyl sulfoxide[J]. Thermochimica Acta, 2013, 559(559):76-81
[15] He F, Chao S, Gao Y, et al. Fabrication of hydrophobic silica-cellulose aerogels by using dimethyl sulfoxide (DMSO) as solvent[J]. Materials Letters, 2014, 137(137):167-169
[16] Wang Q, Zeng H, Song H, et al. Vapor-Liquid equilibria for the ternary system acetonitrile+1-propanol+dimethyl sulfoxide and the corresponding binary systems at 101.3 kPa[J]. J Chem Eng Data, 2010, 55(11):5271-5275
[17] Zhang X, Liu Y, Jian C, et al. Experimental isobaric vapor-liquid equilibrium for ternary system of sec-butyl alcohol+sec-butyl acetate+N,N-dimethyl formamide at 101.3 kPa[J]. Fluid Phase Equilibria, 2014, 383:5-10
[18] Mato F, Cepeda E. Equilibrio liquid-vapor de mezclas binarias formadas por alcoholes y sus esteres del acido acetico. I. Sistemas con metanol, etanol, n-propanol, i-propanol a 760 mmHg[J]. Anal Quim Ser A, 1984, 80:338-342
[19] Belova T P, Epifanova O A, Vanchugova T M, et al. Oniitekhim, Code 1115 KHP-D 1983, 83:1-10
[20] Casimiro F M, Constantino D S M, Pereira C S M, et al. Vapor-Liquid equilibrium of binary mixtures containing isopropyl acetate and alkanols at 101.32 kPa[J]. Journal of Chemical & Engineering Data, 2015, 60(11):3181-3186
[21] 谢扬,沈庆扬.Aspen Plus化工模拟系统在精馏过程中的应用[J]. 化工生产与技术, 1999, 6(3):17-22 Xie Yang, Shen Qingyang. The application of chemical simulation system in distillation process[J]. Chemical Production and Technology, 1999, 6(3):17-22(in Chinese)
[22] 孙兰义. 化工流程模拟实训——Aspen Plus教程[M].北京:化学工业出版社,2012 Sun Lanyi. Chemical engineering process simulation using-Aspen Plus[M]. Beijing:Chemical Industry Press, 2012(in Chinese)
[23] Langston P,Hilal N,Shingfield S,et al.Simulation and optimisation of extractive distillation with water as solvent[J]. Chemical Engineering and Processing:Process Intensification, 2005, 44(3):345-351
[24] Hou J, Xu S, Ding H, et al. Isobaric vapor-liquid equilibrium of the mixture of methyl palmitate and methyl stearate at 0.1 kPa, 1 kPa, 5 kPa, and 10 kPa[J]. Journal of Chemical & Engineering Data, 2012, 57(10):2632-2639
[25] 张瑶芬, 杜玉兰, 刘昆元, 等. 辛烯醛-异辛醇二元体系汽-液平衡研究[J]. 化学工程, 1983, (2):19-24 Zhang Yaofeng, Du Yulan, Liu Kunyuan,et al. The vapor-liquid equilibrium of octene aldehyde-isooctyl alcohol binary system[J]. Chemical Engineering, 1983, (2):19-24(in Chinese)