阳离子聚丙烯酰胺辅助溶剂萃取油砂沥青工艺研究

摘要

使用甲苯、正庚烷、石油醚和石脑油，辅以阳离子聚丙烯酰胺和离子液体等助剂对加拿大亲水型油砂进行了萃取实验，并从沥青回收率、沥青中细沙夹带和残砂形貌3个角度对沥青分离效果进行了分析评价，最终认为阳离子聚丙烯辅助石脑油萃取油砂沥青是一种经济可行的工艺路线。随后文章从助剂浓度、助剂存放时间、助剂和油砂比例、溶剂和油砂比例等角度出发，对工艺参数进行了优化。结果表明，在室温条件下，当石脑油：0.05% CPAM水溶液：油砂为3：2：1时，沥青回收率由72.29%提升至78.29%。此外，通过对沥青的红外分析和残砂的扫描电镜分析还发现，阳离子聚丙烯酰胺在甲苯和石脑油萃取体系中均有夹带减小细砂的功效。

	Service

	把本文推荐给朋友
	加入我的书架
	加入引用管理器
	Email Alert
	RSS
	作者相关文章
	袁逸璞
	何林
	隋红

关键词：油砂；阳离子聚丙烯酰胺；石脑油；细砂夹带

Abstract：

Toluene, n-heptane, petroleum ether and naphtha were used as the solvent to extract bitumen from water-wet oil sands amended with CPAM (cationic polyacrylamide) aqueous solution and pure[Emim]BF₄. The bitumen recovery, infrared spectrum of bitumen and SEM microphotographs of the residual sands/clay constitute the three aspects of evaluation of the solvents and additives. Finally, naphtha amended with CPAM aqueous solution were regarded to be reliable and practical. After the optimization, the bitumen recovery increased from 72.29% to 78.29% while the ratio of naphtha to 0.05% CPAM aqueous solution to oil sands was 3:2:1 at room temperature. In addition, CPAM aqueous solution demonstrated the ability to reduce clay/fines entrainment both in bitumen and naphtha systems.

Keywords： oil sands； CPAM； naphtha； clay fines entrainment

Received 2015-04-29;

Corresponding Authors: 隋红,Email:suihong@tju.edu.cn。 Email: suihong@tju.edu.cn

About author: 袁逸璞(1990-),男,硕士研究生,主要从事油砂分离工艺优化等相关研究。

引用本文:

袁逸璞, 何林, 隋红.阳离子聚丙烯酰胺辅助溶剂萃取油砂沥青工艺研究[J]. 化学工业与工程, 2017,34(2): 73-78

Yuan Yipu, He Lin, Sui Hong.Study on Solvent Extraction Process from Oil Sands Amended with CPAM[J]. Chemcial Industry and Engineering, 2017,34(2): 73-78

[1] 崔苗苗,李文深,李晓鸥,等.油砂资源的开发和利用[J].化学工业与工程,2009,26(1):79-83 Cui Miaomiao, Li Wenshen, Li Xiaoou, et al. Development and utilization of oil sands[J]. Chemical Industry and Engineering, 2009, 26(1):79-83(in Chinese)
[2] 董知军,刘立平,王蓉辉,等.内蒙古扎赉特旗油砂分离[J].石油化工高等学校学报,2005,18(4):31-34 Dong Zhijun, Liu Liping, Wang Ronghui, et al. Separation of Inner Mongolia Jalaid Banner oil sands[J]. Journal of Petrochemical Universities, 2005, 18(4):31-34(in Chinese)
[3] 许修强,王红岩,郑德温,等. 油砂开发利用的研究进展[J]. 辽宁化工,2008,37(4):268-271 Xu Xiuqiang, Wang Hongyan, Zheng Dewen, et al. Research progress in application of the oil sands[J].Liaoning Chemical Industry, 2008, 37(4):268-271(in Chinese)
[4] 邢定峰,龚满英,刘蜀敏,等.加拿大油砂沥青加工方案研究[J].石油规划设计, 2007,18(1):10-14 Xing Dingfeng, Gong Manying, Liu Shumin, et al. Study on the bitumen process of Canadian oil sands[J]. Petroleum Planning & Engineering, 2007, 18(1):10-14(in Chinese)
[5] Dai Q, Chung K H. Bitumen-Sand interaction in oil sand processing[J]. Fuel, 1995, 74(12):1858-1864
[6] Akbarzadeh K, Ayatollahi S, Moshfeghian M, et al. Estimation of SARA fraction properties with the SRK EOS[J]. J Can Petrol Technol, 2004, 43(9):31-39
[7] 杨红强,丁明山,胡斌,等. 水辅助溶剂法提取油砂中的沥青[J]. 化工进展, 2014,33(9):2495-2500 Yang Hongqiang, Ding Mingshan, Hu Bin, et al. Investigation on water-assisted solvent extraction of bitumen from oil sands[J]. Chemical Industry and Engineering Progress, 2014, 33(9):2495-2500(in Chinese)
[8] Masliyah J, Zhou Z, Xu Z, et al. Understanding water-based bitumen extraction from Athabasca oil sands[J]. Can J Chem Eng, 2004, 82(4):628-654
[9] Hooshiar A. Clay minerals in non-aqueous extraction of bitumen from Alberta oil sands:Part 2. Characterization of clay minerals[J]. Fuel Processing Technology, 2012, 96(1):183-194
[10] Painter P, Williams P, Mannebach E. Recovery of bitumen from oil or tar sands using ionic liquids[J]. Energy & Fuels, 2009, 24(2):1094-1098
[11] Li X, Sun W, Wu G, et al. Ionic liquid enhanced solvent extraction for bitumen recovery from oil sands[J]. Energy & Fuels, 2011, 25(11):5224-5231
[12] 杜永亮. 高浓度石油污染土壤溶剂萃取过程的研究[D]. 天津:天津大学, 2012 Du Yongliang. Solvent extraction for oil removal from heavily contaminated soils[D]. Tianjin:Tianjin University, 2012(in Chinese)
[13] Yang H, Wang Y, Ding M, et al. Water-Assisted solvent extraction of bitumen from oil sands[J]. Industrial & Engineering Chemistry Research, 2012, 51(7):3032-3038
[14] 薛福连. "百业助剂"--聚丙烯酰胺前景广阔[J]. 上海化工, 2004, 29(7):49-50 Xue Fulian.[J]. "All-around additives"-Polyacrylamide has broad prospects[J]. Shanghai Chemical Industry, 2004, 29(7):49-50(in Chinese)
[15] 张坚强, 李鑫钢, 隋红. 离子液体促进溶剂萃取油砂沥青[J]. 化工进展, 2014, 33(8):1986-1991 Zhang Jianqiang, Li Xingang, Sui Hong. Solvent extraction of bitumen from oil sands amended with ionic liquid[J]. Chemical Industry and Engineering Progress, 2014, 33(8):1986-1991(in Chinese)
[16] Chen F, Finch J A, Xu Z, et al. Wettability of fine solids extracted from bitumen froth[J]. J Adhes Sci Technol, 1999, 13(10):1209-1224