三相内循环生物流化床内循环时间的研究

摘要采用脉冲示踪法测定了三相内循环生物流化床反应器在不同进气量Q_g、固含率ε_s和升降流区截面积比条件下的循环时间T_C，对反应器的内循环特征和混合情况进行了系统的研究。结果表明：进气量Q_g、固含率ε_s和升降流区截面积比A_r/A_d共同影响了反应器的内循环时间T_C，进气量能在较大范围内调控反应器的循环时间T_C。循环时间T_C随进气量Q_g呈指数衰减，随ε_s的增加而增大，并且最小进气量Q_g,min也随ε_s的增加而升高；随A_r/A_d的增大，T_C总体也呈增大趋势。Q_g为96 L/h时T_C 随ε_s变化的转折点，当Q_g大于96 L/h时，T_C随ε_s的增加显著增大；并进一步讨论了进气量和固含率对反应器的生物处理效率和效果的影响，为反应器的改进、放大和运行提供了可靠的依据。

	Service

	把本文推荐给朋友
	加入我的书架
	加入引用管理器
	Email Alert
	RSS
	作者相关文章
	李振中
	胡堃
	赵明朝
	黄卫星

关键词：三相内循环生物流化床脉冲法循环时间T_C

Abstract： The pulse tracing technique is used to determine the characteristics of the threephase innerloop biological fluidized bed. The internal liquid circulation is analyzed and the effects of the operating conditions, such as air flow rate Q_g, solid content ε_s, and the crosssection area ratio of riser to downcomer A_r/A_d, on circle time T_C are studied. Results show that with other operating conditions keeping constant, T_C is affected significantly by the operating Q_g, ε_s and A_r/A_d, especially by Q_g. T_C decreases with the increase of Q_g following an exponential decay curve obviously; while with the increase of ε_s, T_Cand Q_g,min rise, especially when Q_g > 96 L/h; T_C prolongs with the increasing of A_r/A_d. The effects of Q_gand ε_s on the biodegradation of wastewater are also discussed, the results give reference to the improvement, amplification and operation of bioreactor.

Keywords： threephase circulation biofluidized bed pulse tracing technique circle time T_C

Received 2011-12-01;

Corresponding Authors: 黄卫星，电话：（028）85048126，E-mail: hwx@scu.edu.cn。 Email: hwx@scu.edu.cn

About author: 李振中（1986-），男，河南南阳人，硕士研究生，从事化工过程强化与节能方向的研究。

引用本文:

李振中, 胡堃, 赵明朝, 黄卫星.三相内循环生物流化床内循环时间的研究[J]. 化学工业与工程, 2012,29(3): 46-50

LI Zhen-Zhong, HU Kun, ZHAO Ming-Chao, HUANG Wei-Xing.Internal Circle Time of a ThreePhase InnerLoop Biological Fluidized Bed[J]. Chemcial Industry and Engineering, 2012,29(3): 46-50